|
ISO-25 Material Safety Data Sheet
POLYISO RIGID FOAM SHEET, PIPE AND EQUIPMENT INSULATION
Download these MSDS Sheets in .pdf version | .rtf version | .doc version
DYPLAST PRODUCTS ISO-25 (UNFACED)
MATERIAL SAFETY DATA SHEET
DYPLAST PRODUCTS, LLC
12501 NW 38TH AVENUE
MIAMI, FLORIDA 33054
IMPORTANT: Read this MSDS before handling and disposing of this product and pass this information on to employees, customers, and users of this product. This product is covered by the OSHA Hazard Communication Rule and this document has been prepared in accordance with the MSDS requirements of the rule.
I. General
Trade Name: ISO-25
Telephone Number: (305) 921-0100 MIAMI, FL
Other Names: UNFACED ISO
Chemical Name/Family: POLYISOCYANURATE RIGID INSULATION
DOT Hazardous Materials
Proper Shipping Name: NOT REGULATED (SEE SUPPLEMENT)
Generic Name: POLYISOCYANURATE
DOT Hazard Class: NOT REGULATED
CAS No: PROPRIETARY
Amount: 100%
PEL/TLV: NOT ESTABLISHED
II. Summary of Hazards
Physical Hazards:
Acute Health Effects (Short-Term): CAN BE A MECHANICAL IRRITANT TO SKIN, EYES, & UPPER RESPIRATORY SYSTEM DURING FABRICATION
Chronic Health Effects (Long-Term): STUDIES SHOW NO STATISTICALLY SIGNIFICANT INCREASED RISK OF RESPIRATORY DISEASES
III. Fire and Explosion
Flash Point (Method): UNKNOWN
Auto-ignition Temperature: UNKNOWN
Flammable Limits (% Vol. in Air)
At Normal Atmospheric Temperature and Pressure: Lower: N/A Upper: N/A
Fire and Explosion Hazards: POLYISOCYANURATE FOAM WILL BURN IF EXPOSED TO FLAME OF SUFFICIENT HEAT AND INTENSITY. LIKE OTHER ORGANIC MATERIALS, CAN RELEASE TOXIC SMOKE IF IGNITED.
Extinguishing Media: DRY CHEMICAL, CO 2 , WATER SPRAY, WATER FOG, FOAM, WATER
Special Firefighting Procedures: SELF-CONTAINED BREATHING APPARATUS
IV. Health Hazards
Summary of Acute Hazards: SLIGHT. SEE BELOW ROUTE OF EXPOSURE SIGNS AND SYMPTOMS
Inhalation: NO SIGNIFICANT SIGNS OR SYMPTOMS INDICATIVE OF ANY ADVERSE HEALTH ARE EXPECTED TO OCCUR AS A RESULT OF INHALATION EXPOSURE.
Eye Contact: MAY CAUSE MINOR EYE IRRITATION FROM DUST ORIGINATING FROM FABRICATION.
Skin Absorption: NO SIGNIFICANT SIGNS OR SYMPTOMS INDICATIVE OF ANY ADVERSE HEALTH HAZARD ARE EXPECTED TO OCCUR AS A RESULT OF SKIN ABSORPTION.
Skin Irritation: MAY PRODUCE SLIGHT SKIN IRRITATION.
Ingestion: NO SIGNIFICANT SIGNS OR SYMPTOMS INDICATIVE OF ANY ADVERSE HEALTH HAZARD ARE EXPECTED TO OCCUR AS A RESULT OF INGESTION. PRODUCT IS NOT FOR CONSUMPTION.
Summary Chronic Hazards and Special Health Effects: THE MAJOR COMPONENTS OF THIS PRODUCT HAVE NOT BEEN IDENTIFIED AS SIGNIFICANT HAZARDS IN LONGTERM STUDIES.
NO ADDITIONAL MEDICAL INFORMATION FOUND.
V. Protective Equipment and Other Control Measures
Respiratory: USE MASK DURING FABRICATION. USE NIOSH/OSHA APPROVED RESPIRATORY EQUIPMENT.
Eye: WEAR SAFETY GLASSES OR GOGGLES.
Skin: NOT NORMALLY CONSIDERED A SKIN HAZARD. PRACTICE GOOD PERSONAL HYGIENE.
Engineering Controls: EXERCISE GOOD HOUSEKEEPING PROCEDURES. REMOVE DUST DURING FABRICATION BY VACUUM.
Other Hygienic and Work Practices: PROVIDE ADEQUATE VENTILATION WHEN FABRICATING. REMOVE DUST PROMPTLY.
VI. Occupational Exposure Limits
Substance |
Time |
Source |
Date |
Type |
Value/Units |
NUISANCE DUST (TOTALS) |
OSHA |
1989 |
TWA |
15 MG/MS |
8 HRS |
NUISANCE PARTICULATES |
ACGIH |
1989 |
TWA |
10 MG/M3 |
8 HRS |
NUISANCE DUST (RESP.) |
OSHA |
1989 |
TWA |
5 MG/M3 |
8 HRS |
VII. Emergency and First Aid
Inhalation: REMOVE TO FRESH AIR.
Eye Contact: FLUSH WITH WATER FOR 15-20 MINUTES OR UNTIL IRRITATION CEASES.
Skin Contact: WASH WITH SOAP AND WATER.
Ingestion: IF SWALLOWED, DILUTE WITH WATER. DO NOT INDUCE VOMITING.
Emergency Medical Treatment Procedures: PERSONS WHO DEVELOP SYMPTOMS OF ALLERGY, IRRITATION, RESPIRATORY PROBLEMS OR PUFFINESS AROUND THE EYES SHOULD BE EXAMINED BY A PHYSICIAN AS SOON AS POSSIBLE.
VIII. Spill and Disposal
Precautions If Material is Spilled or Released: NOT APPLICABLE
Waste Disposal Methods: DISPOSAL SHOULD BE IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS.
IX. Components
(This may not be a complete list of components)
Component Name (%) CAS No. Carcinogen
POLYISOCYANURATE <60 NONE NONE
X. Physical and Chemical Data
Boiling Point: NOT APPLICABLE
Viscosity Units, Temp. (Method): NOT APPLICABLE
Dry Point: NOT APPLICABLE
Freezing Point: NOT APPLICABLE
Vapor Pressure: NOT APPLICABLE
Volatile Characteristics: NOT APPLICABLE
Specific Gravity: (H 2 O = 1 at 39.2 � F): NOMINAL 2.0 PCF for ISO-25/2.0
Vapor Sp. Gr. (Air = 1.0 at 60 � - 90 � F): NOT APPLICABLE
Solubility in Water: NOT APPLICABLE
pH: NOT APPLICABLE
Hazardous Polymerization: NOT EXPECTED TO OCCUR
Other Chemical Reactivity: NONE
Stability: STABLE
Other Physical and Chemical Properties: NONE
Appearance and Odor: RIGID TAN CELLULAR PLASTIC. NO ODOR.
Conditions to Avoid: OPEN FLAME OR OTHER IGNITION SOURCES. PROLONGED EXPOSURE TO THE ELEMENTS.
Materials to Avoid: DIRECT APPLICATION OF HOT ASPHALT.
Hazardous Decomposition Products (Fire): LIKE WOOD AND OTHER ORGANIC MATERIALS CAN RELEASE TOXIC SMOKE IF IGNITED
XI. Additional Precautions
Handling, Storage and Decontamination Procedure: WHEN STORED OUTDOORS, STACK AT LEAST 4" ABOVE GROUND LEVEL AND COVER WITH TARPAULINS OR OTHER SUITABLE COVERING. PROTECT FROM MOISTURE.
General Comments: SOME OF THE INFORMATION PRESENTED AND CONCLUSIONS DRAWN HEREIN ARE FROM SOURCES OTHER THAN DIRECT TEST DATA ON THE PRODUCT ITSELF.
XII. Regulatory Information
a. SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA), TITLE III
EXEMPT. APPENDIX H(4) SECTION 1910, 1200(b) AS A MANUFACTURED ITEM a), b), c), AND SECTION 311(e) #10.
b. TOXIC SUBSTANCES CONTROL ACT (TSCA)
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
c. COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY ACT (CERCLA)
NO CHEMICALS IN THIS PRODUCT ARE SUBJECT TO THE REPORTING REQUIREMENTS OF CERCLA.
XIII. Supplement
SHIPPING REGULATIONS
NOT CLASSIFIED AS A HAZARDOUS MATERIAL BY DEPARTMENT OF TRANSPORTATION DEFINITIONS AND HENCE IT IS NOT REGULATED.
Disclaimer of Liability
The information in this MSDS was obtained from sources which we believe are reliable. HOWEVER, THE INFORMATION IS PROVIDED WITHOUT ANY WARRANTY, EXPRESS OR IMPLIED, REGARDING ITS CORRECTNESS.
The conditions or methods of handling, storage, use and disposal of the product are beyond our control and may be beyond our knowledge. FOR THIS AND OTHER REASONS, WE DO NOT ASSUME RESPONSIBILITY AND EXPRESSLY DISCLAIM LIABILITY FOR LOSS, DAMAGE OR EXPENSE ARISING OUT OF OR IN ANY WAY CONNECTED WITH THE HANDLING, STORAGE, USE OR DISPOSAL OF THIS PRODUCT.
________________________________________________________________________________
Qualifications
EQ = Equal
AP = Approximately
TR = Trace
LT = Less Than
GT = Greater Than
N/AP = Not Applicable
N/DA = No Data Available
N/P = No Applicable Information Found
_____________________________________________________________________________________________________________
Disclaimer of Liability
The information in this MSDS was obtained from sources which we believe are reliable. HOWEVER, THE INFORMATION IS PROVIDED WITHOUT ANY WARRANTY, EXPRESS OR IMPLIED, REGARDING ITS CORRECTNESS.
The conditions or methods of handling, storage, use and disposal of the product are beyond our control and may be beyond our knowledge. FOR THIS AND OTHER REASONS, WE DO NOT ASSUME RESPONSIBILITY AND EXPRESSLY DISCLAIM LIABILITY FOR LOSS, DAMAGE OR EXPENSE ARISING OUT OF OR IN ANY WAY CONNECTED WITH THE HANDLING, STORAGE, USE OR DISPOSAL OF THIS PRODUCT.